Chemtex’s Alkalinity Builder and Antiscalant surpasses the performance of other boiler compounds such as Maxtreat 3004, Maxtreat 3006 etc.

Boiler tubes & water contionously accumulates scales as well as can become acidic in presence of air.Corrosion is formed as a result.So this corrosive action needs to be inhibited at any cost.

So pH booster is used for this purpose.It increases the pH of boiler water thus making it more alkaline and less prone to corrosion.The chemical can also remove the sludge & scales from the boiler tubes

Normally the Boiler feed water pH should be at 9.5-10 for avoiding boiler tubes corrosion or rusting due to acidic attack.

The antiscalant property of the product makes it profitable for users for its round the year savings of power and labor, and increase in production. Use of antiscalants is a prime necessity to meet up with production targets.

Application:

Boilers

Major Benefits:-

· Prevention of Scaling

· Minimum downtime required for descaling

· Multipurpose,therefore easy to use

· Power / Fuel saving upto 70%

· Effective heat transfer

· Increase in productivity

Test

H2S – A Silent Ultimatum to Oilfields

H 2 S Scavenger Chemical – Introduction The world has witnessed a substantial increase in E&P of crude oil to meet the need for globalization, leading to drilling of ‘deemed undesirable’ sites, owing to the presence of higher concentration of acidic gases like hydrogen sulphide, carbon dioxide, etc. These hazardous gases require proper measures before disposal or scavenging. Of these, Hydrogen sulphide/ H 2 S is the most threatening one, especially in confined or ill ventilated places. The characteristic rotten egg smell makes H 2 S recognition easy even at lower concentrations. Hydrogen Sulphide is toxic, acidic and extremely corrosive at higher concentrations. Heavier than air, it is found more near base level of the working sites. Then comes its inflammability, which may cause explosive reaction with air molecules. With peroxides, ammonia and other oxidizing chemicals, H 2 S often goes through combustible reactions, ...

Enhance IAQ of Closed Spaces with Air Fumigation: ALSTASAN SILVOX 150 FUME

Chemists around the world have shown considerable interest in various aspects and working of Hydrogen Peroxide as a disinfectant at different concentration. Over the past few years, it has been observed by them that a mere 0.5% of Hydrogen Peroxide shows excellent antiviral property within 60 seconds of application, reason being a strong oxidizing agent which helps in eliminating harmful microorganisms wherever used. It oxidizes the cell molecules, rupturing its whole structure and deactivating its ability to replicate. With silver, it has relatively wider range of biocidal (anti-bacterial and anti-fungal) pursuits than other disinfecting chemicals. Since Hydrogen Peroxide is a strong oxidizing agent and silver shows excellent anti-microbial property, their chemical combination brings a lot to the table as a rapid yet effective disinfecting agent with limited or rather no toxicity. Taking the above ideas into consideration, We at Chemtex Speciality Limited have come up with a brand n...

Chemtex Speciality Limited

Search This Blog